Exhaust Gas Recirculation (EGR) Valve Issues

We can also use our tuning diagnostic equipment and software to clean/repair any EGR Valve issues.

Do you need the EGR Valve?

When your cars original EGR system becomes blocked, dysfunctional and effects your economy we can perform an EGR software clean/repair.

It’s a simple easy job to do in most cases. The EGR sorftware clean/repair removes all the problems associated in your cars fault EGR system. Most new electronic EGR systems can cost around £500 plus your labour.

EGR valve repair can improved performance,thermal efficiency, fuel consumption and smoke emissions.

A software clean/repair can Eliminate carbon build up inside the inlet manifold, which in turn reduces air flow effecting the fuel/air ratio.

Online booking available

Diesel Particular Filter (DPF) Clean/Delete

DPF Cleaning:

We diagnose your vehicle and repair any faulty DPF sensors, measure the soot load by diagnostics in your DPF and then chemically treat the DPF. The next stage is to add chemicals to your diesel so that your car efficiently burns it. Finally we perform a forced regeneration of the DPF and measure the soot load again to make sure that it has been reduced.

If your car/van has lower miles on the clock and you have been using good quality diesel then the more likely of long term success with our cleaning process.

If your car is showing a DPF fault or not regenerating you may get some of the following symptoms:

  • The car will go into a reduced power mode.
  • Engine warning lights may come up on your dashboard.
  • You may smell exhaust gases inside your car.
  • Your miles per gallon may be reduced.

Once any of the above symptoms happen in your vehicle bring it into Automotive Service Centre and we will be able to help.

Online booking available

Horsepower

When the ECU comes from the factory it is configured conservatively including power settings.  It is configured to work it all types of conditions and the same for multiple countries.  Chip tuning can change the fuel to air ratio and the vehicles timing to give your car extra power and torque.

More Fuel Efficiency

As well as more performance car tuning can also be setup to improve your mpg.  This can be at the sacrifice of a bit of horsepower but it depends on what you are looking to achieve from an ecu software upgrade.

 

Cleaner Burn

If you tune your car/van you will get a cleaner burn, the more efficiency, more power and less build up you’ll have.  This kind of fine tuning means that you will have to more selective in your fuel choices, but it can pay off in a big way.

 

Check out our online booking & availability here